Middleby-marshall PS640E User Manual

OWNER'S OPERATING ANDINSTALLATION MANUALfor domestic and standard export ovens©2007 Middleby Marshall Inc.is a registered trademark of Middleby M

ITEM NO. QTY PART NO. DESCRIPTION1 1 60287 COMPLETE BASE WELDMENT2 4 37900-0102 TOP PLATE, LEG WELDMENT3 2 22290-0009 SWIVEL CASTER W/BRAKE FLAT PLATE

ITEM NO. QTY PART NO. DESCRIPTION1 1 60287 COMPLETE BASE WELDMENT2 4 45209 QUAD OUTRIGGER WELDMENT3 2 22290-0009 SWIVEL CASTER, W/BRAKE FLAT PLATE4 2

III. VENTILATION SYSTEMB. RecommendationsNOTE THAT THE HOOD DIMENSIONS SHOWN INFIGURE 2-5 ARE RECOMMENDATIONS ONLY.LOCAL, NATIONAL AND INTERNATIONAL C

IV. ASSEMBLYA. Top Panel and Base Pad Assembly1. Install the four leg extensions onto the base pad usingthe 3/8″-16 × 1″ screws, 3/8″ flat washers, an

NOTE:DO NOT install top panel onto double or tripleovens until AFTER stacking the oven cavities. SeePart B, Stacking.B. StackingFor single ovens, skip

D. Conveyor Installation1. Unfold the conveyor as shown in Figure 2-12. Then, beginto slide the conveyor into the end of the oven. Theconveyor can onl

5. If it is necessary to add or remove conveyor links toachieve the correct tension, OR if it is necessary toreverse the conveyor belt for correct ori

13III. ELECTRICAL CONNECTION INFORMATIONFOR PS640E-SERIES OVENS.WARNINGAuthorized supplier personnel normally accom-plish the connections for the vent

14UTILITY ROUGH-IN DIMENSIONS AND POSITIONING FOR PS640-SERIES OVENSFigure 2-19. Typical PS640-Series Oven(s)InstallationTo O v e nTo O v e nWARNINGD

SECTION 3 - OPERATIONLOCATION AND DESCRIPTION OF CONTROLSA. Main On/Off ButtonTurns all oven functions on or off. If the oven is below the setpoint, i

iiWARNINGImproper installation, adjustment, alteration, service, or maintenance can causeproperty damage, injury, or death. Read the installation, op

NORMAL OPERATION - STEP-BY-STEPA. Main Screen1. When the unit has been “OFF” for more than 1 minutethe controller will display the screen saver, as sh

4. To change the conveyor belt speed, push the “TIME”button. The controller will display the screen, shown inFigure 3-5. To change the minute setting,

III. QUICK REFERENCE: TROUBLESHOOTINGSYMPTOM PROBLEM SOLUTIONNo electrical power • Check that the circuit breaker/fused disconnect is on.Make sure th

Vents onfront panelof ovenFan grills (3) on rearof oven and controlcompartmentVents (2) on rearof machinerycompartmentSECTION 4 - MAINTENANCEWARNINGPo

II. MAINTENANCE – MONTHLYNOTE:When removing the conveyor, refer to Figure 2-12 (inSection 2, Installation).A. Check that the oven is cool and the pow

III. MAINTENANCE – EVERY 3 MONTHSA. Check that the oven is cool and the power is discon-nected, as described in the warning at the beginning ofthis S

Figure 4-6. Disassembling the drive shaftE. Blower Belt1. Remove the eight screws shown in Figure 4-7. Then,remove the rear panel from the oven.2. Ch

V. KEY SPARE PARTS – Available separately. See Figure 4-8.Figure 4-8. Key Spare Parts23ITEM QTY. P/N DESCRIPTION1 1 60191 DIGITAL DISPLAY, PROGRAMM

24SECTION 5TROUBLESHOOTINGPROBLEM:PRODUCTS ARE OVERCOOKEDOR UNDERCOOKEDCheck for correctsetting of conveyorspeed control.Set the conveyor speedcontrol

25SECTION 6 - WIRING DIAGRAMMiddleby-Marshall Model Number E208-240 Volt 50/60 Hz, 3 Phase60227 Rev. A4

iiiMIDDLEBY MARSHALL INC.OVEN LIMITED WARRANTY(Non U.S.A.)The Seller warrants equipment manufactured by it to be free fromdefects in material and work

26Middleby-Marshall Model Number E380-480 Volt 50/60 Hz, 3 Phase60231 Rev. A4

27NOTES

Middleby Cooking Systems Group • 1400 Toastmaster Drive • Elgin, IL 60120 • USA • (847)741-3300 • FAX (847)741-4406www.middleby.comMiddleby is proud t

ivNOTEWiring Diagrams are in Section 6 of this Manual.The diagram for each oven is also on the lowerinner surface of its Control Console.PageSECTION 1

I. OVEN USESPS640 Series Ovens can be used to bake and/or cook a widevariety of food products, such as pizza, pizza –type products,cookies, sandwiches

2I. OVEN SPECIFICATIONSTable 1-1 DimensionsSingle Oven Double Oven Triple OvenOverall Height 48-3/16″ (1219mm) 62-3/4″ (1575mm) 78-11/16″ (1981mm)Over

SECTION 2 – INSTALLATIONWARNING – After any conversions, readjustments, or service work on the oven:• Check that the ventilation system is in operatio

PS640 OVEN INSTALLATIONREQUIRED KITS AND EQUIPMENTPS640 PS640 PS640 PS640Electric Oven Single Oven DoubleOven TripleOvenInstallation Option Base w/ Op

Figure 2-2. Model PS640 Single OvenOption Base with Legs and TopPARTS LIST FOR PS640 SERIES SINGLE OVEN OPTION - BASE w/15″″″″″ LEGS & TOPP/N 59